News

Spiders cause Mazda recall for second time

Spiders cause Mazda recall for second time

Photo: Reuters/Arnd Wiegmann

(Reuters) – For the second time in three years, Mazda Motor Corp has issued a recall for Mazda6 sedans in North America because of a spider that likes the smell of gasoline and weaves a web that blocks a vent in the engine.

Mazda told U.S. regulators that it is recalling 42,000 sedans with 2.5-liter engines from model years 2010 to 2012 in the United States. Mazda officials were not immediately available to report recalls outside of the United States.

Three years ago, Mazda recalled about 65,000 Mazda6 sedans in North America from model years 2009 and 2010, also because of spider webs blocking evaporative canister vent lines. The same issue is the cause of the most recent recall, Mazda told the National Highway Traffic Safety Administration.

The web weaved by a spider can lead to a restriction of fuel flow, which in turn can reduce fuel tank pressure when the emission control system purges vapors from the evaporative canister. This can put stress on the fuel tank, which may crack and leak fuel, increasing the risk of a fire, a report filed with NHTSA says.

Mazda said it is not aware of any fires because of this risk.

In 2011, Reuters reported that the Yellow Sac spider was the culprit in that year’s recall. It just likes the smell of gasoline, an auto analyst told Reuters at the time.

Mazda attempted to remedy the problem by adding a spring to the canister vent line to keep spiders from crawling inside.

For the most part, that solution worked, but after several reports of cracked fuel tanks in sedans equipped with the spring, Mazda engineers tried to figure out the spider’s route to the canister.

After learning of nine cases in which tanks were damaged even though a spring was loaded, engineers determined that a change in the car’s software would keep tanks from cracking even if a spider web blocks a vent.

Mazda will inform owners in the recall campaign to bring cars to dealers, where the evaporative canister vent line will be checked and cleared if necessary. Also, the dealerships will reprogram software.

The blockage is not present on other models made by Mazda and occurs only in cars made a plant in Flat Rock, Michigan, at which Mazda once produced cars jointly with Ford Motor Co. Mazda stopped production of cars at Flat Rock in August 2012.

Recent Headlines

58 mins ago in Local

Health Organizations in Nebraska Watching the Zika Virus

Fresh
mosquito

Health organizations are carefully monitoring the spread of the Zika virus after a large outbreak in May of last year in Brazil.

8 hours ago in Local

Property Tax Debate Continues in Nebraska

nebraska-state-capital

Governor Pete Ricketts told a legislative committee Nebraskans demand property tax relief...and the Unicameral needs to respond this year.

10 hours ago in Local

SD Legislature Keeps Conceal Carry Bill Alive

ruger gun

The South Dakota House State Affairs Committee narrowly passed a bill that would allow people with an enhanced concealed weapons permit to possess those weapons in the state Capital and any county courthouse.

11 hours ago in Local

SD Counties Have to Wait for Additional Dollars

state capitol pierre

South Dakota Governor Dennis Daugaard has told county commissions to “be patient” as money from taxes and fees that were raised last year flow to local governments.

21 hours ago in Local

Minnesota Governor Dayton See Fire Damage in Medelia

dayton

Minnesota Governor Mark Dayton was in Madelia and got a first-hand-look at the damage from this week's fire that leveled several businesses along Main Street.